Local atomic structures of an amorphous Mg65Cu25Gd10 alloy and the structural changes by thermal annealing have been studied by extended X-ray absorption fine structure （EXAFS）. The correlation between structural changes and mechanical properties for the Mg65Cu25Gd10 alloy has also been discussed. Results showed that Cu atoms around Gd in Mg65Cu25Gd10 lost rapidly during annealing , resulting in the segregation of Cu atoms. The coordination number NGd-Mg of Mg65Cu25Gd10 annealed at 373 K first diminished and then augmented with the increase of annealing time. The formation of polyhedral short-range order unit with coordination number of nearly 12 around Gd atoms is in favor of the improvement of mechanical properties. The chemical short-range order, not topological short-range order in the amorphous Mg65Cu25Gd10 alloy had obvious changes during annealing.
The effect of substitutional element Zn on corrosion behavior of Mg65Cu25Gd10 glass was investigated. The amorphous structure of Mg65Cu25-xZnxGd10 （x=0,5） alloys were examined by X-ray diffractometry and differential scanning calorimetry （DSC）. The dissolution rates of Mg65Cu25-xZnxGd10 （x=0, 5） metallic glasses in a 5 wt% NaCl solution with pH value of 7 were determined by a hydrogen evolution testing method. The corrosion behavior of these alloys was characterized using dipping tests with 5 wt% NaCl, in combination with electrochemical measurements and scanning electron microscopy （SEM）. Results show that the anti-corrosion ability of Mg65Cu25Gd10 alloy is significantly improved due to the addition of Zn. Possible mechanism responsible for the improvement is discussed.
To identify the re-arrangement of constituent atoms of an amorphous Mg65Cu25Gd10 alloy happened with annealing, structure relaxation of the alloy was investigated as a function of an- nealing time at 373 K through extended X-ray absorption fine structure （EXAFS） analysis procedures. To understand the effect of structure relaxation on strength, compression tests were conducted for both the as-cast and the annealed Mg65Cu25Gd10 samples. It is found that short range order around Cu and Gd atoms exhibits different variation trends with increasing annealing time at 373 K, though the structure of the alloy still remains to be amorphous. Based on the fact that the strength of the alloy first exhibits a reduction and then a recovery with annealing time, it is suggested that the enhancement of short range order around Cu should be responsible for the strength reduction, while the enhancement of short range order around Gd should be responsible for the strength recovery.
